欢迎访问恒安机械网站,为您提供层流手术室净化,GMP车间净化公司,山东无尘车间的相关信息。
咨询热线:18653160053
新闻资讯 news
联系我们 CONTACT

地址:济南市槐荫区美里路丽水华庭

电话:18653160053

QQ:850206910

新闻资讯 您当前的位置:首页 - 新闻资讯 >

如何选择层流手术室净化工程的用料

来源:http://www.henganjh.cn │ 发表时间:2019-06-17 

  如何选择层流手术室净化工程的用料
  How to Select Materials for Laminar Flow Operating Room Purification Project
  如何选择层流手术室净化工程的用料,干净手术部的特性是中心工程、形象工程和半永世性的基建工程,因而其选型资料也必需从这三点动身,至少保证十年以上寿命,并分离功用需求,完成用材比较佳的性价比,层流手术室净化的工程用材选择罗列如下:
  How to select materials for laminar flow operating room purification project? The characteristics of clean operating room are central engineering, image engineering and semi-permanent infrastructure engineering. Therefore, the selection of materials must start from these three points to ensure at least 10 years of life, and separate functional requirements to achieve the best cost-performance ratio. The selection of materials for laminar flow operating room purification project is listed as follows:
  1.墙面、吊顶用材
  1. Material for wall and ceiling
  由于干净手术室、干净走廊(包括换车间)是整个干净手术部比较关键的部位,因而其装饰用材要优于其它部位的资料,同时满足其美观、防锈、防腐、耐擦洗、易清洁、不起尘、耐用的请求,并且其装置构造方式也要契合手术室的特性。其中吊顶的面层资料由于受损伤的时机较少,因而能够比墙材低一个层次。
  Because clean operating room and clean corridor (including changing workshop) are the most critical parts of the whole clean operating department, the decorative materials are superior to those of other parts, while meeting the requirements of beauty, rust-proof, anti-corrosion, anti-scrubbing, easy cleaning, dust-free and durable, and the structure of the device should also conform to the characteristics of the operating room. Among them, the surface data of suspended roof can be one level lower than wall material because of the less time of damage.
  2.干净辅房、清洁走廊、清洁区辅房的墙面吊顶用材
  2. Wall ceiling materials for clean auxiliary rooms, clean corridors and clean area auxiliary rooms
  由于干净辅房、清洁走廊、清洁区辅房相关于干净手术室和干净走廊来说是净化手术部相对次要的部位,而且常常面积还比拟大,为了降低造价,其墙材、吊顶用材能够比手术室、干净走廊选材低一个层次。
  Because clean auxiliary rooms, clean corridors, clean area auxiliary rooms are relatively minor parts of clean operating rooms and clean corridors, and often the area is comparatively large, in order to reduce the cost, the wall materials and ceiling materials can be one level lower than those of operating rooms and clean corridors.
  3.手术部空中资料
  3. Aerial Data of Operating Department
  手术室的空中用材出于其功用性的请求,必需契合抗着色、抗静电、耐磨、吸音好的特性,因而橡胶地材是首选。 而手术部其它走廊及辅房由于人流量较多,因而地材比较突出的请求便是耐磨。为了降低造价,能够选择比橡胶地材差的PVC同质地材即可。
  For the purpose of its function, the air materials in operating room must fit the characteristics of anti-dyeing, anti-static, wear-resisting and sound-absorbing, so rubber floor materials are the first choice. The other corridors and auxiliary rooms in the operation Department have a large flow of people, so the most prominent request for floor materials is wear resistance. In order to reduce the cost, we can choose PVC homogeneous material which is worse than rubber floor material.
层流手术室净化
  4.净化空气处置机组
  4. Purified Air Disposal Unit
  鉴别净化空气处置机组的好坏,主要看以下几点:
  To distinguish the quality of purified air disposal units, the following points should be considered:
  A.能否是卫生型的机组?由于卫生型机组的检测指标比普通型的要高,并且其构造方式更契合净化理念;
  A. Can it be a sanitary unit? Because the detection index of sanitary units is higher than that of ordinary units, and its construction mode is more in line with the concept of purification.
  B.风机的性能须经过权威机构检测,并有相应的标签,性能才有保证;
  B. The performance of fans must be tested by authoritative organizations and have corresponding labels to ensure their performance.
  C.漏风率越低,防结露性能越好(要提供检测报告),机组越好;
  C. The lower the air leakage rate, the better the anti-condensation performance (to provide test reports), the better the unit;
  D.在同等技术条件下,噪音越低越好;
  D. Under the same technical conditions, the lower the noise, the better.
  E.外观设计、制造工艺的好坏;
  E. Appearance design and manufacturing technology;
  5.层流集中送风安装
  5. Laminar centralized air supply installation
  层流集中送风安装位于手术室净化送风系统的未端,是整个净化系统中比较洁净的部位,这一部位的好坏对净化系统空气干净度指标影响很大,这一点需特别关注。
  Laminar centralized air supply is installed at the end of the air supply system in the operating room, which is the cleanest part of the whole air purification system. The quality of this part has a great impact on the air cleanliness index of the air purification system, which needs special attention.
  6.过滤器
  6. High Efficiency Filter
  过滤器的性能好坏取决于两个方面的要素
  The performance of high efficiency filters depends on two factors
  A.对0-3μm尘埃粒子的过滤效率,它取决于滤纸资料的好坏;
  A. The filtration efficiency of 0-3 um dust particles depends on the quality of filter paper data.
  B. 能否逐台检漏,过滤器是很柔嫩的,一个针眼大的小孔就会使其报废,因而不做逐台检漏,无法保证其性能。
  B. Whether leak detection can be done step by step, the high-efficiency filter is very tender. A small hole with a big pinhole will make it scrapped. Therefore, without leak detection step by step, its performance can not be guaranteed.
  以上就是层流手术室净化工程所需的用料,大家应该都曾经理解了吧,假如想要理解更多的相关内容,请继续关注我们公司的网站http://www.henganjh.cn,或许从中会找到你想要的答案,或者联络我们的工作人员,进行咨询。
  These are the materials needed for laminar flow operating room purification project, you should have understood it, if you want to understand more relevant content, please continue to pay attention to our company's website http://www.henganjh.cn, perhaps you will find the answer you want, or contact our staff for consultation.

上一篇:山东无尘车间的装修要求是什么?
下一篇:GMP车间净化公司的预防、控制和维护管理